#1 2009-09-09 08:42:03

Rory_y

Member

Registered: 2009-09-09

Posts: 2

Re: 08 Rhino 700 FI - Starts hard and won't idle

I live in Costa Rica and the nearest dealer is 100 miles away.  I purchased my Rhino in the states and shipped it here.  It ran fine for the first 1500 miles, and now it dies when you come to a stop and is very difficult to restart.  I went through the onboard diagnostics and there are no fault codes stored.  The sensors check out ok.  It will run down the road, but won't idle.  I've removed the gas cap and air filter, but neither had any effect on the problem.  I checked and there is plenty of fule getting to the injector.  Does anyone have any experience or suggestions with this issue?  Help!

RANGERDALEXP

Member

From: Palmdale, Ca.

Registered: 2008-09-02

Posts: 902

Re: 08 Rhino 700 FI - Starts hard and won't idle

I live in Costa Rica and the nearest dealer is 100 miles away.  I purchased my Rhino in the states and shipped it here.  It ran fine for the first 1500 miles, and now it dies when you come to a stop and is very difficult to restart.  I went through the onboard diagnostics and there are no fault codes stored.  The sensors check out ok.  It will run down the road, but won't idle.  I've removed the gas cap and air filter, but neither had any effect on the problem.  I checked and there is plenty of fule getting to the injector.  Does anyone have any experience or suggestions with this issue?  Help!

I normally deal with the Polaris stuff but i think i can point you in the proper direction. Your Rhino has what they call an (ISC) idle speed control unit and if it is bad or not working properly the engine will not idle. Also check your fuel pressure and make sure it is at 46 psi. The only other thing is it could be the (TPS) throttle position sensor but i would bet it is the ISC causing the problem. Hope this helps  .

---

2003 Ford F350 Superduty FX4 Lariat, Banks Kit.
2003 Rampage 365 Toy Hauler.
2005 Ranger Xp, Sp belt, EPI Clutch Kit, Sp Ecu.
2001 Honda XR650R With Go Fast Kit.
[img]http://i388.photobucket.com/albums/oo330/RANGERDALEXP/JAWBONESNOW11jpg-1.jpg[/img][img]http://i388.photobucket.com/albums/oo330/RANGERDALEXP/aniranger_blue11.gif[/img]
All data and information provided from my postings is for informational purposes only. Rangerdalexp makes no representations as to accuracy, completeness, currentness, suitability, or validity of any information on this site and will not be liable for any errors, omissions, or delays in this information or any losses, injuries, or damages arising from its display or use. All information is provided on an as-is basis used for reference only.